Now hiring technicians! Click here

Book your Service or Repair Now!

Be prepared  Special Offers

How do you know when your trailer needs new brakes?

Sep 28, 2020 | Trailer

What are the telltale signs the brakes on your trailer are worn and it’s time for an inspection? After a trip, or, once per year is wise. Even if the brakes have had little use, load and weight may cause uneven wear on your braking system.

Some obvious signs that your brakes are in need of replacement include noise, pulling, pulsing and pedal depression during braking. In extreme situations of brake failure or brake component failures, your wheels can lock up while travelling, causing severe tire damage and it will smoke out drivers travelling behind you. This is what happened to the customer of this project. Fortunately for the client, nobody was injured. However, to get the trailer to Pro World, the customer disabled the brakes (not advised!) by draining the brake fluid from the reservoir. What this means is the the client was travelling with a trailer that had no active brakes which was not only illegal, it was unsafe.

Once Joe cracked into this project he said “the bearings are in shambles and partially siezed, which is what rendered these brakes unmovable. I dealt with one that was so bad one time, the wheel actually came off the axle”.

After Joe cleaned all the debris out of the hub he had to make certain the spindle didn’t have any bad grooves which is what the bearings will ride on. Because brake pads are porous and there was grease all over the old brake pads, those had to be replaced along with the bearings. As you can see from the images below, the backing plates were heavily rusted and also had a significant amount of grease on them too. Therefore, bearings, brake pads, seals, races and brake plates all had to be replaced. Often, it’s more cost-effective and better for the braking system to install new backing plates. The brake lines were old, brittle and leaking, so we replaced those too.

Most importantly, when you perform brake replacements on an axle, both sides have to be replaced. When you hear or feel the first signs that something isn’t working right, it’s time to book an appointment for an inspection. If you are uncertain and have questions about your brakes, feel free to call us. We’re here for you. Learn more about trailer services here.

https://youtu.be/prmsXKgwaT0

 

Airstream Buff & Shine

What goes into an Airstream buff and shine? An unbelievable amount of muscle, several layers of rubbing compound, polish and a polishing wheel. Repeat process. This Airstream was neglected for over 30 years, so there's a lot of old grime and layers to remove. How much...

Vehicle & Trailer Restoration

Many people today are interested in purchasing older RV’s and trailers that have unique and nostalgic qualities. We understand the attraction, and enjoy working on all makes and the earliest models. For some people, their purchase is an obsession and they will stop at...

The top 10 things that go wrong with trailers

TOP 10 THINGS THAT GO WRONG WITH TRAILERS A lot can go wrong with your trailer, and you won't even know it! Here are the top 10 things that should be checked at least once per year, or following a trip. You don't want to incur unnecessary expenses on trailer repairs...

The RV experts

Click here to view our full range of services to keep the wheels rolling

trailer specialists

Be prepared for a smooth drive with professsional trailer services

trailerable boats and watercraft

Winterization, maintenance & repair, custom fabrication & consoles, gel coating and more

Protection from the top down

Get Roof Preventative Maintenance for tip-top assurance. You'll avoid expensive and unexpected repairs or even replacement.

Includes: Inspect the roof seals. Seal the front and rear caps and roof fixture seams. If we discover extensive water leaks are present and require work beyond our standard preventative maintenance, you will receive a new estimate. Side molding seams are not included.

Leaky roofs wreak havoc

One of the most common issues with RV's is a leaky roof. While you may think you can leave your recreation vehicle out in the elements like you would a small vehicle, this is a huge mistake. RV's and trailers have large seams that weaken over time, due to the elements...

Airstream Buff & Shine

What goes into an Airstream buff and shine? An unbelievable amount of muscle, several layers of rubbing compound, polish and a polishing wheel. Repeat process. This Airstream was neglected for over 30 years, so there's a lot of old grime and layers to remove. How much...

Vehicle & Trailer Restoration

Many people today are interested in purchasing older RV’s and trailers that have unique and nostalgic qualities. We understand the attraction, and enjoy working on all makes and the earliest models. For some people, their purchase is an obsession and they will stop at...

The top 10 things that go wrong with trailers

TOP 10 THINGS THAT GO WRONG WITH TRAILERS A lot can go wrong with your trailer, and you won't even know it! Here are the top 10 things that should be checked at least once per year, or following a trip. You don't want to incur unnecessary expenses on trailer repairs...

As always, RV Pro came through again. They chased down an electrical issue I had with my class "C" and they finished a day early! The staff is very friendly and the Tech explained what he found and left the defective parts for me to see.

Bob T - Google Review

Contact Us

418 Repass Road Vancouver, WA  98665

Mon-Fri 7:30AM–3:30PM, Sat-Sun Closed

 

Telephone

(360) 993-5880

Pro World Newsletter

Join the Pro World News

Get RV news you can use, and be the first to receive special offers.  

Email sent, check your inbox!